Molecules2013,18,13812-13822:doi:10.3390/molecules181113812 OPEN ACCESS molecules I1SSN1420-3049 www.mdpi.com/journal/molecules Article Baeyer-Villiger Oxidation of Some Ci Steroids by Penicillium lanosocoeruleum Alina Swizdor Department of Chemistry,Wroclaw University of Environmental and Life Sciences,Norwida 25 Wroclaw 50-375,Poland;E-Mail:alina.swizdor@up.wroc.pl;Tel.:+48-71-3205-252; Fax:+48-71-3284-124 Received:8 September 2013:in revised form:28 October 2013/Accepted:30 October 2013/ Published:7 November 2013 Abstract:The biotransformation of androsterone(1),epiandrosterone(2),androstanedione (3)and DHEA(dehydroepiandrosterone)(4)by Penicillium lanosocoeruleum-a fungal species not used in biotransformations so far-were described.All the substrates were onverted in high yield(70%9%)into D ring -lactones.The oxidation of 1 produced 3a-hydroxy-17a-oxa-D-homo-5a-androstan-17-one (5).The oxidation of 2 led to 3B-hydroxy-17a-oxa-D-homo-5a-androstan-17-one(6).The biotransformation of 3 resulted in the formation of 3a-hydroxy-17a-oxa-D-homo-5a-androstan-17-one (5)and 17a-oxa-D- homo-5a-androstan-3,17-dione(7).An analysis of the transformation progress of the studied substrates as a function of time indicates that the Baeyer-Villiger monooxygenase of this fungus does not accept the 3B-hydroxy-5-ene functionality of steroids.In this microorganism steroidal 3B-hydroxy-dehydrogenase (3B-HSD)was active,and as a result DHEA (4)was transformed exclusively to testololactone (8).Apart from the observed oxidative transformations,a reductive pathway was revealed with the C-3 ketone being reduced to a C-3a-alcohol.It is demonstrated for the first time that the reduction of the 3-keto group of the steroid nucleus can occur in the presence of a ring-D lactone functionality. Keywords: steroidal lactones; biotransformation;Baeyer-Villiger oxidation DHEA:androsterone;epiandrosterone;5a-androstan-3,17-dione; 3那-HSD: Penicillium lanosocoeruleum
Molecules 2013, 18, 13812-13822; doi:10.3390/molecules181113812 molecules ISSN 1420-3049 www.mdpi.com/journal/molecules Article Baeyer-Villiger Oxidation of Some C19 Steroids by Penicillium lanosocoeruleum Alina Świzdor Department of Chemistry, Wroclaw University of Environmental and Life Sciences, Norwida 25, Wroclaw 50-375, Poland; E-Mail: alina.swizdor@up.wroc.pl; Tel.: +48-71-3205-252; Fax: +48-71-3284-124 Received: 8 September 2013; in revised form: 28 October 2013 / Accepted: 30 October 2013 / Published: 7 November 2013 Abstract: The biotransformation of androsterone (1), epiandrosterone (2), androstanedione (3) and DHEA (dehydroepiandrosterone) (4) by Penicillium lanosocoeruleum—a fungal species not used in biotransformations so far—were described. All the substrates were converted in high yield (70%–99%) into D ring δ-lactones. The oxidation of 1 produced 3α-hydroxy-17a-oxa-D-homo-5α-androstan-17-one (5). The oxidation of 2 led to 3β-hydroxy-17a-oxa-D-homo-5α-androstan-17-one (6). The biotransformation of 3 resulted in the formation of 3α-hydroxy-17a-oxa-D-homo-5α-androstan-17-one (5) and 17a-oxa-Dhomo-5α-androstan-3,17-dione (7). An analysis of the transformation progress of the studied substrates as a function of time indicates that the Baeyer-Villiger monooxygenase of this fungus does not accept the 3β-hydroxy-5-ene functionality of steroids. In this microorganism steroidal 3β-hydroxy-dehydrogenase (3β-HSD) was active, and as a result DHEA (4) was transformed exclusively to testololactone (8). Apart from the observed oxidative transformations, a reductive pathway was revealed with the C-3 ketone being reduced to a C-3α-alcohol. It is demonstrated for the first time that the reduction of the 3-keto group of the steroid nucleus can occur in the presence of a ring-D lactone functionality. Keywords: steroidal lactones; biotransformation; Baeyer-Villiger oxidation; DHEA; androsterone; epiandrosterone; 5α-androstan-3,17-dione; 3β-HSD; Penicillium lanosocoeruleum OPEN ACCESS
Molecules 2013.18 13813 1.Introduction Steroids represent an important class of natural products with varying pharmacological properties. Minor modifications in their structure may affect their bioactivity,consequently,research on the preparation of potentially useful steroid analogues is being continued for development of processes exploitable by the pharmaceutical industry.Biotransformations are powerful tools for generation of novel steroidal drugs,as well as for efficient production of steroidal key intermediates.In the majority of cases,these modifications have been achieved by the use of whole-cells microorganisms.The use of enzymes ensures the high regio-and stereoselectivity of the reaction to be performed,and biotransformations are more environmentally friendly in comparison with chemical syntheses Microbial transformations of various steroids have been reviewed recently [121 Currently research efforts in production of steroids of pharmaceutical interest are focused on either optimization of existing processes or identification of novel potentially useful bioconversions. It is not surprising that several microorganisms have been reported to exhibit Baeyer-Villiger oxidation properties.Only in a few cases the isolated enzymes have been used [1,3,4].Recently. cyclopentadecanone monooxygenase (CPDMO)isolated from Pseudomonas sp.,involved in the catabolism of cyclopentadecanone in Nature,was also found to accept steroids as substrates [3].It has been screened for the Baeyer-Villiger oxidation of a large number of steroids but the products were formed in low yields.The use of the chimeric enzyme PASTMO(a hybrid of phenylacetone monooxygenase (PAMO)and bacterial steroid monooxygenase (STMO)from Rhodococcus rhodochrous)in the biotransformation of progesterone afforded the final lactone(testololactone)with a moderate(19%)conversion []Among microorganisms,fungal species of the Penicillium [5-10] Aspergillus [11-20 and Fusarium genera [21-23]are especially known to transform 4-en-3-oxo and 3B-hvdroxy-5-ene Ca as well as cia steroids.Enzymes performing oxidation belong to the family of NADPH-dependent steroid Baeyer-Villiger monooxygenases(BVMOs)containing FAD as a cofactor. The catalytic activity of this class of enzymes is manifested in the transformation of C-20 ketones into the corresponding acetates,which then hydrolyze to the related C-17 alcohols,followed by oxidation to ketones,and finally ring-D Baeyer-Villiger oxidation gives lactones. Steroidal lactones are important compounds due to their biological activity such as anticancer and antiandrogenic action.It was found that they could inhibit the 5a-reductase,and as a result of this block the conversion of testosterone to 5a-dihydrotestosterone [24]and therefore have therapeutic potential for the treatment of androgen-dependent diseases.Steroidal testolactone as an inhibitor of steroidal aromatase 25],is used in the clinical treatment of breast cancer 25]and a few forms of precocious puberty [26].Although chemical synthesis routes to steroidal ring-D lactones using peracids [27,28]are possible,they often result in a larger variety of products (e.g,regioisomeric lactones,epoxylactones or epoxyketones). Microbial steroid BVMOs are steroid-induced enzymes,which utilize atmospheric oxygen as oxidant.Their catalytic properties exhibit differences [even within the same species of microorganism.For example,Penicillium citreo-viride oxidized androstenedione,progesterone and DHEA (dehydroepiandrosterone)to testololactone,while pregnenolone was not transformed; conversion of DHEA to testololactone occurred through the 3B-hydroxysteroid dehydrogenase/5-ene-4 ene isomerase pathway resulting in the generation of a 4-en-3-oxo system in the steroid ring-A [7]
Molecules 2013, 18 13813 1. Introduction Steroids represent an important class of natural products with varying pharmacological properties. Minor modifications in their structure may affect their bioactivity, consequently, research on the preparation of potentially useful steroid analogues is being continued for development of processes exploitable by the pharmaceutical industry. Biotransformations are powerful tools for generation of novel steroidal drugs, as well as for efficient production of steroidal key intermediates. In the majority of cases, these modifications have been achieved by the use of whole-cells microorganisms. The use of enzymes ensures the high regio- and stereoselectivity of the reaction to be performed, and biotransformations are more environmentally friendly in comparison with chemical syntheses. Microbial transformations of various steroids have been reviewed recently [1,2]. Currently research efforts in production of steroids of pharmaceutical interest are focused on either optimization of existing processes or identification of novel potentially useful bioconversions. It is not surprising that several microorganisms have been reported to exhibit Baeyer-Villiger oxidation properties. Only in a few cases the isolated enzymes have been used [1,3,4]. Recently, cyclopentadecanone monooxygenase (CPDMO) isolated from Pseudomonas sp., involved in the catabolism of cyclopentadecanone in Nature, was also found to accept steroids as substrates [3]. It has been screened for the Baeyer-Villiger oxidation of a large number of steroids but the products were formed in low yields. The use of the chimeric enzyme PASTMO (a hybrid of phenylacetone monooxygenase (PAMO) and bacterial steroid monooxygenase (STMO) from Rhodococcus rhodochrous) in the biotransformation of progesterone afforded the final lactone (testololactone) with a moderate (19%) conversion [4]. Among microorganisms, fungal species of the Penicillium [5–10], Aspergillus [11–20] and Fusarium genera [21–23] are especially known to transform 4-en-3-oxo and 3β-hydroxy-5-ene C21 as well as C19 steroids. Enzymes performing oxidation belong to the family of NADPH-dependent steroid Baeyer-Villiger monooxygenases (BVMOs) containing FAD as a cofactor. The catalytic activity of this class of enzymes is manifested in the transformation of C-20 ketones into the corresponding acetates, which then hydrolyze to the related C-17 alcohols, followed by oxidation to ketones, and finally ring-D Baeyer-Villiger oxidation gives lactones. Steroidal lactones are important compounds due to their biological activity such as anticancer and antiandrogenic action. It was found that they could inhibit the 5α-reductase, and as a result of this, block the conversion of testosterone to 5α-dihydrotestosterone [24] and therefore have therapeutic potential for the treatment of androgen-dependent diseases. Steroidal testolactone as an inhibitor of steroidal aromatase [25], is used in the clinical treatment of breast cancer [25] and a few forms of precocious puberty [26]. Although chemical synthesis routes to steroidal ring-D lactones using peracids [27,28] are possible, they often result in a larger variety of products (e.g., regioisomeric lactones, epoxylactones or epoxyketones). Microbial steroid BVMOs are steroid-induced enzymes, which utilize atmospheric oxygen as oxidant. Their catalytic properties exhibit differences [1], even within the same species of microorganism. For example, Penicillium citreo-viride oxidized androstenedione, progesterone and DHEA (dehydroepiandrosterone) to testololactone, while pregnenolone was not transformed; conversion of DHEA to testololactone occurred through the 3β-hydroxysteroid dehydrogenase/5-ene-4- ene isomerase pathway resulting in the generation of a 4-en-3-oxo system in the steroid ring-A [7]
Molecules 2013.18 13814 This same pathway was observed during the transformation of DHEA by P.griseopurpureum and P.glabrum [In contrast to P.citreo-viride,BVMO(s)from P.lilacinum accepted 3-hydroxy-5-ene substrates [6].The enzyme was able to carry out the degradation of 17B-acetyl side chain and ring-D lactonization of 3B-hydroxy-5-ene as well as 4-en-3-oxo substrates with preference for lactonization of 5-ene steroids.In this way DHEA was converted only to 3B-hydroxy-17a-oxa-D-homo-androst-5-en- 17-one(a D-lactone with conserved ring-A moiety),whereas pregnenolone was also transformed to testololactone (a D-lactone with a 3-ox0-4-ene system).P.camemberti was able to carry out the oxidation of pregnenolone and DHEA to testololactone.which could be formed via two routes through 4-en-3-ketone or 3B-hydroxylactone [9].In most cases of transformations described in literature,the steroids,besides the Baeyer-Villiger oxidation,aso underwent hydroxylation,reduction or dehydrogenation [8,12,15,16,19,23,29].The mixtures of metabolites formed during the transformations led to difficulties in product purification.The processes were usually slow(2-5 days) and the productivity was low. In the light of our interest [6,9.29]in the microbial Baeyer-Villiger oxidation of steroids,this article reports the results of the transformation of a series of androstanes,namely DHEA epiandrosterone,androsterone and androstanedione,by Penicillium lanosocoeruleum KCH 3012.To the best of the author's knowledge,this is the first report of the use of P.lanosocoeruleum in biotransformations. 2.Results and Discussion The P.lanosocoeruleum KCH 3012 strain produces a Baeyer-Villiger monooxygenase which is able to carry out the regioselective ring-D lactonization of 5a-dihydro-steroids (1-3)as well as unsaturated steroid 4(Scheme 1,Table 1).The corresponding lactones5and 6.were formed with high vield (70%-96%)as the sole products from epimeric 3-hydroxy substrates-androsterone (1)and epiandrosterone (2).Two lactones:3a-hydroxy-17a-oxa-D-homo-5a-androstan-17-one (5)and 17a-oxa-D-homo-5a-androstan-3,17-dione (7)were isolated after transformation of a 3,17-diketo compound-androstanedione(3).DHEA(4)was converted to testololactone(8). Scheme 1.Structures of substrates and products of their transformations. 3R-0 7R-0
Molecules 2013, 18 13814 This same pathway was observed during the transformation of DHEA by P. griseopurpureum and P. glabrum [8]. In contrast to P. citreo-viride, BVMO(s) from P. lilacinum accepted 3β-hydroxy-5-ene substrates [6]. The enzyme was able to carry out the degradation of 17β-acetyl side chain and ring-D lactonization of 3β-hydroxy-5-ene as well as 4-en-3-oxo substrates with preference for lactonization of 5-ene steroids. In this way DHEA was converted only to 3β-hydroxy-17a-oxa-D-homo-androst-5-en- 17-one (a D-lactone with conserved ring-A moiety), whereas pregnenolone was also transformed to testololactone (a D-lactone with a 3-oxo-4-ene system). P. camemberti was able to carry out the oxidation of pregnenolone and DHEA to testololactone, which could be formed via two routes: through 4-en-3-ketone or 3β-hydroxylactone [9]. In most cases of transformations described in literature, the steroids, besides the Baeyer-Villiger oxidation, also underwent hydroxylation, reduction or dehydrogenation [8,12,15,16,19,23,29]. The mixtures of metabolites formed during the transformations led to difficulties in product purification. The processes were usually slow (2–5 days) and the productivity was low. In the light of our interest [6,9,29] in the microbial Baeyer-Villiger oxidation of steroids, this article reports the results of the transformation of a series of androstanes, namely DHEA, epiandrosterone, androsterone and androstanedione, by Penicillium lanosocoeruleum KCH 3012. To the best of the author’s knowledge, this is the first report of the use of P. lanosocoeruleum in biotransformations. 2. Results and Discussion The P. lanosocoeruleum KCH 3012 strain produces a Baeyer-Villiger monooxygenase which is able to carry out the regioselective ring-D lactonization of 5α-dihydro-steroids (1–3) as well as unsaturated steroid 4 (Scheme 1, Table 1). The corresponding lactones 5 and 6, were formed with high yield (70%–96%) as the sole products from epimeric 3-hydroxy substrates—androsterone (1) and epiandrosterone (2). Two lactones: 3α-hydroxy-17a-oxa-D-homo-5α-androstan-17-one (5) and 17a-oxa-D-homo-5α-androstan-3,17-dione (7) were isolated after transformation of a 3,17-diketo compound—androstanedione (3). DHEA (4) was converted to testololactone (8). Scheme 1. Structures of substrates and products of their transformations. O H R H R O O O HO O O O 1 R=α-OH 2 R=β-OH 3 R=O 5 R=α-OH 6 R=β-OH 7 R=O 4 8
Molecules 2013.18 13815 Table 1.The results of transformation of 1-4 and 7 by P.lanosocoeruleum. Starting material Time h Compounds Yield (%)动 48 Ba-Hydroxy-l7a oxa-D-homo-5a-androstan-17-one(5) 98(96 Epiandrosterone(2) 48 drosterone (2) 1917) 3B-Hydroxy-17a-oxa-D-homo-5a-androstan-17-one(6) 75(70) Androstanedione (3) 24 Androstanedione(3) 17a-Oxa-D-homo-5a-androstan-3.17-dione (7) 40(37 3a-Hydroxy-17a-oxa-D-homo-5a-androstan-17-one(5) 59(55) DHEA(4) 24 DHEA (4) Testololactone (8) 96191ù 17a-Oxa-D-homo- 48 17a-Oxa-D-hom -5a-androstan-3,17-dione(7) 2423) 5a-androstan-3,17-dione(7) 3a-Hydroxy-17a-oxa-D-homo a-androstan-17-one(5) 71(67) Determined by GC analysis of the crude chloroform extracts.Isolated yield in parentheses The structures of the obtained products were established by using spectroscopic techniques (IR. H-NMR and C-NMR).The assumed structures were confirmed by comparison of the characteristic shift values of selected,diagnostic signals of products and starting compounds.Resonance signals in both H-NMR and C-NMR spectra of all metabolites 5-8 suggested the formation of the ring-D lactones.The absence of the carbonyl group signals at c ca.220 ppm,the presence of new signals at c ca.171 ppm and downfield shifts of the C-13 resonance signals with respect to the substrates confirmed insertion of an oxygen atom into the ring-D.The oxygen insertion into ring-D of all metabolites as suppored by significant downfield shifts for both the -methyl in H-NMR and the C-18 signals inC-NMR.The bands at 1714-1720 cm in the IR spectra of the products confirmed the 8-lactone structures.The absence of the 3a-H resonance(m)from the H-NMR spectrum of the metabolite 8 coupled with an increase in the C-19 methyl resonance signal (A 0.14 ppm relative to substrate 4)and a shift of the signal of olefinic proton from oH 5.36 ppm to 5.75 ppm indicated isomerization of the double bond with its formation between C-4 and C-5 and Ca的8 c C-5 was visible at 169.1 ppm and its position was consistent with the position of a B-carbon conjugated with the carbonyl group.Oxidation of the 3B-OH group was fully supported by the loss of a methine signal at 8 71.5 ppm in the starting material'C-NMR spectrum,being replaced by a new non-protonated resonance signal in the product spectrum at1994 ppm.All these observations for metabolites 5-8 were in agreement with those reported in the literature [6.17.18.301. 3a-Hydroxy-17a-oxa-D-homo-5a-androstan-17-one(5)was previously obtained in 53%yield by transformation of androsterone using Aspergillus tamarii KITA,but it was one of the six metabolites produced from this substrate.During that transformation,substrate as well as 3a-hydroxy-17a-oxa-D- homo-5a-androstan-17-one also underwent hydroxylation,giving a mixture of 1-and 11B-hydroxy products [16].Epiandrosterone was converted to 3B-hydroxy-17a-oxa-D-homo-5a-androstan-17-one (6)with 10%vield by Aspergillus terreus [181.17a-Oxa-D-homo-5a-androstan-3.17-dione (7)was previously obtained with 29%yield as one of the three metabolites by transformation of
Molecules 2013, 18 13815 Table 1. The results of transformation of 1–4 and 7 by P. lanosocoeruleum. Starting material Time (h) Compounds Yield (%) a,b Androsterone (1) 48 Androsterone (1) - 3α-Hydroxy-17a-oxa-D-homo-5α-androstan-17-one (5) 98 (96) Epiandrosterone (2) 48 Epiandrosterone (2) 19 (17) 3β-Hydroxy-17a-oxa-D-homo-5α-androstan-17-one (6) 75 (70) Androstanedione (3) 24 Androstanedione (3) - 17a-Oxa-D-homo-5α-androstan-3,17-dione (7) 40 (37) 3α-Hydroxy-17a-oxa-D-homo-5α-androstan-17-one (5) 59 (55) DHEA (4) 24 DHEA (4) - Testololactone (8) 96 (91) 17a-Oxa-D-homo- 5α-androstan-3,17-dione (7) 48 17a-Oxa-D-homo-5α-androstan-3,17-dione (7) 3α-Hydroxy-17a-oxa-D-homo-5α-androstan-17-one (5) 24 (23) 71 (67) a Determined by GC analysis of the crude chloroform extracts. b Isolated yield in parentheses. The structures of the obtained products were established by using spectroscopic techniques (IR, 1 H-NMR and 13C-NMR). The assumed structures were confirmed by comparison of the characteristic shift values of selected, diagnostic signals of products and starting compounds. Resonance signals in both 1 H-NMR and 13C-NMR spectra of all metabolites 5–8 suggested the formation of the ring-D lactones. The absence of the carbonyl group signals at δC ca. 220 ppm, the presence of new signals at δC ca. 171 ppm and downfield shifts of the C-13 resonance signals with respect to the substrates, confirmed insertion of an oxygen atom into the ring-D. The oxygen insertion into ring-D of all metabolites was supported by significant downfield shifts for both the 18-methyl protons’ signals in 1 H-NMR and the C-18 signals in 13C-NMR. The bands at 1714–1720 cm−1 in the IR spectra of the products confirmed the δ-lactone structures. The absence of the 3α-H resonance (m) from the 1 H-NMR spectrum of the metabolite 8 coupled with an increase in the C-19 methyl resonance signal (∆ 0.14 ppm relative to substrate 4) and a shift of the signal of olefinic proton from δH 5.36 ppm to δH 5.75 ppm indicated isomerization of the double bond with its formation between C-4 and C-5 and oxidation of the C-3 alcohol to a ketone. Double bond migration into ring-A was fully supported in the 13C-NMR spectrum with downfield shifts observed for C-4 (∆ 81.8 ppm) and C-5 (∆ 28.1 ppm). Signal C-5 was visible at δc 169.1 ppm and its position was consistent with the position of a β-carbon conjugated with the carbonyl group. Oxidation of the 3β-OH group was fully supported by the loss of a methine signal at δc 71.5 ppm in the starting material 13C-NMR spectrum, being replaced by a new non-protonated resonance signal in the product spectrum at δc 199.4 ppm. All these observations for metabolites 5–8 were in agreement with those reported in the literature [6,17,18,30]. 3α-Hydroxy-17a-oxa-D-homo-5α-androstan-17-one (5) was previously obtained in 53% yield by transformation of androsterone using Aspergillus tamarii KITA, but it was one of the six metabolites produced from this substrate. During that transformation, substrate as well as 3α-hydroxy-17a-oxa-Dhomo-5α-androstan-17-one also underwent hydroxylation, giving a mixture of 1β- and 11β-hydroxy products [16]. Epiandrosterone was converted to 3β-hydroxy-17a-oxa-D-homo-5α-androstan-17-one (6) with 10% yield by Aspergillus terreus [18]. 17a-Oxa-D-homo-5α-androstan-3,17-dione (7) was previously obtained with 29% yield as one of the three metabolites by transformation of
Molecules 2013,18 13816 5a-pregna-3,20-dione using Aspergillus tamarii KITA [11].Testololactone(8)was the only product of the transformation of Cr C-oxo-4-ene steroids or DHEA and androstenediol by P.cire-viride as well as progesterone by A.terreus [18].This lactone was prepared with 32%-86%yield,depending on the substrate and the used biocatalyst The composition of mixtures sampled after various transformation periods was studied in order to investigate the metabolic pathways of 3 and 4(Table 2).The reaction mixture after 8 h of incubation of androstanedione(3)contained,apart from the substrate,%of androsterone (1)and %of 3-keto-D- lactone 7.That result indicated that substrate 3 underwent transformation via two routes:through stereoselective ketone reduction at C-3 and Baeyer-Villiger oxidation in ring-D.The rapid increase in the contents of D-lactones 5 and 7 between8 and 12 h of the incubation indicates that compound 1 as well as compound 3 are the inducers of the bVMo responsible for the lactonization of C-17-ketones In the product mixture obtained after 12 h and 24 h of transformation of androstanedione(3)the 3-oxo-lactone 7 prevailed.but its content decreased with prolonged reaction time.and consequently after 48 h of incubation.the main metabolite of 3 was 3a-hydroxy-17a-oxa-D-homo-5a-androstan-17- one(5).Because the amount of accumulating androsterone(1)did not exceed 10%it can be assumed that lactone 5 was formed mainly from lactone 7 (Scheme 2).It was shown in a separate experiment that the 3-keto-lactone 7 was converted by p.lanososoeruleum to the 3a-hydroxv-lactone 5.This is apparently the first time that the reduction of the 3-keto group has been observed in the presence of the lactone functionality in ring-D Table 2.Time course of the transformation of androstanedione(3)and DHEA(4). Rt Substrate (min) Compounds present in the mixture)Time of transformation() 48122448 Androstanedione(3) Androstanedione(3) 1009526 3.15 Andr osterone(1) 7.19 3a-Hydroxy-17a-oxa-D-homo-5a- 2440 androstan-17-one (5) 59 17a-Oxa-D-homo-5a-androstan-3.17- 7.60 2405439 dione (7) DHEA(4) 3.39DHEA(4) 85261 442 Androstenedione (9) 1563584 8 42 Testololactone (8) 114094 38-hydroxy-17a 6.77 -oxa-D-homo-androst-5- en 17-0 Determined by GC analysis.Identified in GC and TLC on the basis of standard.The standard obtained in our previous work6. The analysis of composition of mixtures after transformation of dHea (4)indicated that the first stage of the process was the oxidative conversion of 3B-hydroxy-5-ene to 3-oxo-4-ene functionality (Scheme 3,Table 2).Androstenedione(9)was the only metabolite identified after 4 h incubation of 4: the mixtures after 8 h and 12 h incubation contained a significant amount of 9.After 12 h of reaction, the content of androstenedione in the reaction mixtures started to decrease.Simultaneously,the conten of testololactone(8)increased.The production of 8 reached a maximum at 24 h of the experiment
Molecules 2013, 18 13816 5α-pregna-3,20-dione using Aspergillus tamarii KITA [11]. Testololactone (8) was the only product of the transformation of C19 or C21 3-oxo-4-ene steroids or DHEA and androstenediol by P. citreo-viride [7], as well as progesterone by A. terreus [18]. This lactone was prepared with 32%–86% yield, depending on the substrate and the used biocatalyst. The composition of mixtures sampled after various transformation periods was studied in order to investigate the metabolic pathways of 3 and 4 (Table 2). The reaction mixture after 8 h of incubation of androstanedione (3) contained, apart from the substrate, 3% of androsterone (1) and 2% of 3-keto-Dlactone 7. That result indicated that substrate 3 underwent transformation via two routes: through stereoselective ketone reduction at C-3 and Baeyer-Villiger oxidation in ring-D. The rapid increase in the contents of D-lactones 5 and 7 between 8 and 12 h of the incubation indicates that compound 1 as well as compound 3 are the inducers of the BVMO responsible for the lactonization of C-17-ketones. In the product mixture obtained after 12 h and 24 h of transformation of androstanedione (3) the 3-oxo-lactone 7 prevailed, but its content decreased with prolonged reaction time, and consequently after 48 h of incubation, the main metabolite of 3 was 3α-hydroxy-17a-oxa-D-homo-5α-androstan-17- one (5). Because the amount of accumulating androsterone (1) did not exceed 10%, it can be assumed that lactone 5 was formed mainly from lactone 7 (Scheme 2). It was shown in a separate experiment that the 3-keto-lactone 7 was converted by P. lanososoeruleum to the 3α-hydroxy-lactone 5. This is apparently the first time that the reduction of the 3-keto group has been observed in the presence of the lactone functionality in ring-D. Table 2. Time course of the transformation of androstanedione (3) and DHEA (4). Substrate Rt (min) Compounds present in the mixture (%) a Time of transformation (h) 4 8 12 24 48 Androstanedione (3) 3.75 Androstanedione (3) 100 95 26 5 - 3.15 Androsterone (1) - 3 8 - - 7.19 3α-Hydroxy-17a-oxa-D-homo-5α- androstan-17-one (5) - - 24 40 59 7.60 17a-Oxa-D-homo-5α-androstan-3,17- dione (7) - 2 40 54 39 DHEA (4) 3.39 DHEA (4) 85 26 1 - 4.42 Androstenedione (9) b 15 63 58 4 8.42 Testololactone (8) - 11 40 94 6.77 3β-hydroxy-17a-oxa-D-homo-androst-5- en-17-one c - - - - a Determined by GC analysis. b Identified in GC and TLC on the basis of standard. c The standard obtained in our previous work [6]. The analysis of composition of mixtures after transformation of DHEA (4) indicated that the first stage of the process was the oxidative conversion of 3β-hydroxy-5-ene to 3-oxo-4-ene functionality (Scheme 3, Table 2). Androstenedione (9) was the only metabolite identified after 4 h incubation of 4; the mixtures after 8 h and 12 h incubation contained a significant amount of 9. After 12 h of reaction, the content of androstenedione in the reaction mixtures started to decrease. Simultaneously, the content of testololactone (8) increased. The production of 8 reached a maximum at 24 h of the experiment